Product ID:S-30A NIGHT SEALANT
MSDS Date:04/04/1995
FSC:8030
NIIN:00F047209
MSDS Number: BZCLZ

FIRESTONE BUILDING PRODUCTS CO

525 CONGRESSIONAL BLVD
CARMEL, IN 46032-5000
US

Emergency Phone: 615-231-3911/317-575-7190

Info Phone: 615-231-3911/317-575-7190

Cage: FIRES

FIRESTONE BUILDING PRODUCTS CO

CARMEL, IN 46032-5000 US

Telephone: 615-231-3911

Cage: FIRES

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: <17%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

CLAY (KAOLIN), ALUMINUM SILICATE *96-1*

CAS: 1332-58-7

RTECS: GF1670500

Fraction By Weight: <5%

ACGIH TLV: 10 MG/CUM TOTAL DUST

SILICA, AMORPHOUS FUMED (IARC CARCINOGEN - GROUP 3) *96-1*

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: <5%

OSHA PEL 0.1 MG/CUM

ACGIH TLV: 0.1 MG/CUM

TOLUENE (IARC CARC- GROUP 3) *96-1*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 36%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS INGREDIENTS

Fraction By Weight: >51%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION, DERMATITIS. ABSORPTION THROUGH INTACT SKIN MAY
CONTRIBUTE TO OVERALL EXPOSURE. INHALATION: RESPIRATORY SYSTEM
IRRITATION & CNS DEPRESSION, TOLUENE VAPORS >20 0 PPM MAY RESULT IN
IMPAIRMENT OF COORDINATION. MAY CAUSE KIDNEY & SPLEEN DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DRYING OF THE SKIN, HEADACHE, DIZZINESS, MUSCULAR WEAKNESS,
FATIGUE. TOLUENE VAPORS >200 PPM: INCREASED REACTION TIME & BAD
TASTE IN THE MOUTH & UNCONSCIO USNESS.

First Aid:EYES: WASH W/WATER FOR 15 MINS. SKIN: CLEAN W/RUBBING ALCOHOL
FIRST, FOLLOWED IMMEDIATELY BY WASHING W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:45F
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM/WATER FOG.
Fire Fighting Procedures:DON'T USE DIRECT STREAM OF WATER. PRODUCT WILL
FLOAT & CAN BE REIGNITED ON THE SURFACE OF THE WATER. WEAR
IMPERMEABLE PROTECTIVE CLOTHING & SCBA.
Unusual Fire/Explosion Hazard:HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. COOL W/WATER STREAM.

Spill Release Procedures:REMOVE IGNITION SOURCES. ASBORB ON INERT
MATERIAL. USE NON-SPARKING TOOLS. PLACE IN SECURE CONTAINERS FOR
DISPOSAL.

Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES. KEEP
CONTAINERS CLOSED. VAPORS ARE HEAVIER THAN AIR & WILL COLLECT IN
LOW/CONFINED AREAS.
Other Precautions:CONTAINERS, EVEN EMPTY, CAN CONTAIN EXPLOSIVE VAPORS.
DON'T CUT, DRILL, GRIND, WELD ON/NEAR CONTAINERS. STATIC
ELECTRICITY MAY ACCUMULATE & CREATE A FIRE HAZARD. GROUND FIXED
EQUIPMENT. BOND & GROUND ALL TRANSFER CONTAINERS & EQUIPMENT.

Respiratory Protection:IF EXPOSURE LIMITS CAN'T BE MAINTAINED BELOW
EXPOSURE LIMITS USING ENGINEERING CONTROLS, USE A NIOSH APPROVED
ORGANIC VAPOR AIR PURIFYING RESPIRATOR. USE AIR SUPPLIED/SCBA
RESPIRATORS. WHEN EXPOSURE L EVELS ARE UNKNOWN.
Ventilation:REQUIRED
Protective Gloves:NITRILE/POLYVINYL ALCOHOL
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:CHEMICAL SPLASH GOGGLES.
Supplemental Safety and Health

Boiling Pt:B.P. Text:232F
Vapor Pres:22
Vapor Density:>1
Spec Gravity:0.945
Evaporation Rate & Reference:(ETHER =1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID W/AROMATIC ODOR.
Percent Volatiles by Volume:<40

Stability Indicator/Materials to Avoid:YES
ACIDS, ALKALIES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES, SPARKS & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:COMBUSTION: CO2, CO, OXIDES OF
NITROGEN, HYDROGEN CHLORIDE, VARIOUS HYDROCARBONS, PHENOLS, ACRID
SMOKE, IRRITATING FUMES

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID UN1133.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.